Research of the measurement method for the pressure distribution along the micro/mini-channel
-
摘要: 设计并搭建了一套微小通道沿程压力的测量系统，包括PMMA通道和压力方腔、微应变传感器及多通道应变仪等。利用注射泵的推进方法提供微通道静压，采用FCO510型高精度微差压计的测量值作为标准压力，通过多通道应变仪测量微通道方腔中各个应变片的应变值，从而建立标准压力和应变之间的标定函数。分别对3种微压芯片在80、70、60及50mL/min等4种不同流量下的压力分布进行了测量，压力分布具有良好的线性规律。不确定度分析表明压力误差的相对扩展不确定度范围为0.15%~6.82%，测量结果的有效性和可靠性较高。Abstract: In this study, a system was designed and built up for the pressure measurement along micro/mini-channel, which mainly includes micro/mini-channel and square pressure cavities on PMMA chip, micro-strain sensors and multi-channel strain instruments. The static pressure in micro/mini-channel was provided by the syringe pump, and the high precision pressure values measured by the micromanometer of FCO510 was employed as the standard pressure. The strain values from the strain sensors installed on the square pressure cavities were obtained by multi-channels strain gauge, and the calibration functions between the standard pressure and the strain were established. The pressure distributions of three kinds of micro pressure chips were measured under flow rates of 80, 70, 60 and 50mL/min, respectively. The pressures have good linear distribution.The uncertainty analysis indicates that the relative uncertainty of the pressure error is between 0.15% and 6.82%. The validity and reliability of pressure measurement are high.
-
Key words:
- micro/mini-channel /
- pressure along the channel /
- strain measurement /
- uncertainty
-
图 4 标定曲线和函数.(a)~(c)对应3种通道的情况
Figure 4. Calibration curves and functions. (a)~(c) for three kinds of channels, respectively
图 5 沿程压力测量值结果.(a)~(c)对应3种通道的情况
Figure 5. Measurement results of pressures along the channels.(a)~(c) for three kinds of channels, respectively
表 1 DH3818N-2型应变仪参数
Table 1. Strain instrument parameters of DH3818N-2
参数 技术指标 测量通道数 20 适用应变片电阻值 50~10000Ω 应变片灵敏度系数 1.0~3.0自动修正 采样速率 2Hz/通道 测量应变范围 ±30000με 系统示值误差 不大于0.5% 最高分辨率 0.5με 
下载: 导出CSV
表 2 3组微压芯片尺寸参数
Table 2. Scales of three kinds of pressure chip
芯片 芯片尺寸/mm 通道尺寸/mm 方腔尺寸/mm Type1 80×30×4 68×2.5×1 4×1.5×1 Type2 80×30×4 68×1.5×1 3×1.5×1 Type3 80×30×4 58×1×0.5 2×1×0.5
下载: 导出CSV
表 3 2种型号应变片的主要参数
Table 3. The main parameters of two strain gauges
参数 KFG-1 KFG-5 基底尺寸/mm 4.8×2.4 9.4×2.8 敏感栅长/mm 1 5 电阻值/Ω 120.4±0.4 119.6±0.4 灵敏度系数/% 2.13±1 2.09±1
下载: 导出CSV
表 4 第1组所有测点压力测量不确定度评定结果
Table 4. Uncertainty evaluation results of all pressure measurement points of type 1 channel
测点距离
/mm测量不确定度/% 流量
80mL/min流量
70mL/min流量
60mL/min流量
50mL/min5 2.16 0.45 0.96 2.71 10 0.68 1.87 1.03 0.83 15 1.32 0.52 0.26 0.75 20 1.51 2.98 2.57 1.24 25 2.94 3.01 3.81 3.08 30 1.27 1.34 1.89 1.39 35 3.84 3.73 2.75 3.79 40 2.11 1.29 0.94 2.13 45 3.76 2.84 3.76 3.88 50 4.18 5.17 6.13 1.91 55 3.97 3.26 2.32 5.46 60 6.53 6.02 4.75 5.73
下载: 导出CSV
表 5 第2组不同测点压力测量不确定度评定结果
Table 5. Uncertainty evaluation results of all pressure measurement points of type 2 channel
测点距离
/mm测量不确定度/% 流量
80mL/min流量
70mL/min流量
60mL/min流量
50mL/min5 2.05 2.49 2.08 2.17 10 1.62 1.86 1.07 2.38 15 1.96 0.36 2.43 0.29 20 0.77 1.03 1.75 1.04 25 0.84 2.68 2.16 3.18 35 1.04 1.39 1.18 0.36 40 3.27 3.12 2.94 3.77 45 2.83 1.18 1.36 1.64 50 4.65 3.42 6.76 6.73 55 3.29 2.07 1.61 5.41 60 6.73 5.26 6.82 4.95
下载: 导出CSV
表 6 第3组不同测点压力测量不确定度评定结果
Table 6. Uncertainty evaluation results of all pressure measurement points of type 3 channel
测点距离/mm 测量不确定度/% 流量
80mL/min流量
70mL/min流量
60mL/min流量
50mL/min5 1.84 2.67 1.06 1.05 10 1.03 1.85 0.15 1.13 15 0.96 0.33 1.04 0.98 20 0.31 1.27 0.51 1.02 25 1.26 2.64 1.46 1.39 30 0.28 0.58 1.52 2.04 35 1.13 1.35 0.27 2.18 40 4.84 5.62 4.89 4.96 45 5.16 4.17 5.63 0.83 50 0.72 3.43 6.12 4.64
下载: 导出CSV
-
[1] 杨梅, 于炜, 张莹, 等.梁-膜结构微压传感器研制[J].实验流体力学, 2010, 24(2):74-76. http://www.syltlx.com/CN/abstract/abstract9809.shtmlYang M, Yu W, Zhang Y, et al. Development of a beam-membrane structure micro-pressure sensor[J]. Journal of Experiments in Fluid Mechanics, 2010, 24(2):74-76. http://www.syltlx.com/CN/abstract/abstract9809.shtml [2] 常莹, 马炳和, 邓进军, 等.基于微型压力传感器阵列的翼面压力分布直接测量系统[J].实验流体力学, 2008, 22(3):89-93. http://www.syltlx.com/CN/abstract/abstract9658.shtmlChang Y, Ma B H, Deng J J, et al. Direct measurement system of pressure distribution on airfoil surface using micro pressure sensor array[J]. Journal of Experiments in Fluid Mechanics, 2008, 22(3):89-93. http://www.syltlx.com/CN/abstract/abstract9658.shtml [3] Pong K C, Ho C M, Liu J Q, et al. Non-linear pressure distribution in uniform microchannels[C]. American Society of Mechanical Engineers, Fluids Engineering Division (Publication) FED, 1994, 197:51-56. https://www.researchgate.net/publication/284035378_Non-linear_pressure_distribution_in_uniform_microchannels [4] Ko H S, Liu C W, Gau C, et al. Flow characteristics in a microchannel system integrated with arrays of micro-pressure sensors using a polymer material[J]. Journal of Micromechanics and Microengineering, 2008, 18(7):75016. doi: 10.1088/0960-1317/18/7/075016 [5] Wang L, Ding T, Wang P. Thin flexible pressure sensor array based on carbon black/silicone rubber nanocomposite[J]. IEEE Sensors Journal, 2009, 9(9):1130-1135. doi: 10.1109/JSEN.2009.2026467 [6] Li H, Luo C X, Ji H, et al. Micro-pressure sensor made of conductive PDMS for microfluidic applications[J]. Microelectronic Engineering, 2010, 87(5-8):1266-1269. doi: 10.1016/j.mee.2009.11.005 [7] Foland S, Liu K, Macfarlane D, et al. High-sensitivity microfluidic pressure sensor using a membrane-embedded resonant optical grating[J]. Sensor, 2011:101-104. http://ieeexplore.ieee.org/abstract/document/6127285 [8] Jung T, Yang S. Highly stable liquid metal-based pressure sensor integrated with a microfluidic channel[J]. Sensors, 2014, 15(5):11823-11829. http://www.mdpi.com/1424-8220/15/5/11823/html [9] Tsai C H D, Nakamura T, Kaneko M. An on-chip, electricity-free and single-layer pressure sensor for microfluidic applications[C]. International Conference on Intelligent Robots and Systems, IEEE, 2015. http://ieeexplore.ieee.org/xpl/articleDetails.jsp?arnumber=7353369 [10] Yeo J C, Yu J, Zhao M K, et al. Wearable pressure sensors based on flexible microfluidics[J]. Lab on a Chip, 2016, 16(17):3244-3250. doi: 10.1039/C6LC00579A [11] Song S H, Gillies G T, Begley M R, et al. Inductively coupled microfluidic pressure meter for monitoring of cerebrospinal fluid shunt function[J]. Journal of Medical Engineering and Technology, 2012, 36(3):156-162. doi: 10.3109/03091902.2011.645943 [12] Wu C Y, Liao W H, Tung Y C. A seamlessly integrated microfluidic pressure sensor based on an ionic liquid electrofluidic circuit[C]. International Conference on Micro Electro Mechanical Systems. 2011:1087-1090. http://ieeexplore.ieee.org/xpls/abs_all.jsp?arnumber=5734618 [13] 张有康, 甘蓉.压力传感器测量中不确定度的评定[J].中国测试技术, 2005, 31(6):25-26. http://kns.cnki.net/KCMS/detail/detail.aspx?filename=sycs200506006&dbname=CJFD&dbcode=CJFQZhang Y K, Gan R. Evaluation of strain gauge measurement uncertainty of pressure transducer[J]. China Measurement Technology, 2005, 31(6):25-26. http://kns.cnki.net/KCMS/detail/detail.aspx?filename=sycs200506006&dbname=CJFD&dbcode=CJFQ -
下载:
点击查看大图
计量
- 文章访问数: 246
- HTML全文浏览量: 102
- PDF下载量: 0
- 被引次数: 0
京公网安备 11010502036328号 京ICP备17033152号