基于非定常气动特性的高架动车组振动特性试验研究

黄尊地; 常宁

doi:10.3901/JME.2022.24.233

基于非定常气动特性的高架动车组振动特性试验研究

doi: 10.3901/JME.2022.24.233

黄尊地^{1, 2,},
常宁^1,*, ,

1.
五邑大学轨道交通学院江门 529020
2.
中南大学交通运输工程学院长沙 410075

基金项目:

广东省基础与应用基础研究基金区域联合基金-青年基金 2019A1515111052

广东省教育厅“创新强校工程” 2017KQNCX205

详细信息

作者简介:
黄尊地, 男, 1987年出生, 副教授, 硕士研究生导师。主要研究方向为轨道交通空气动力学。E-mail: wyuhzd@163.com

通讯作者:
常宁(通信作者), 女, 1984年出生, 讲师。主要研究方向为轨道交通车辆工程。E-mail: wydxcn@163.com

中图分类号: U270
计量
- 文章访问数: 7
- HTML全文浏览量: 8
- PDF下载量: 0
- 被引次数: 0
出版历程
- 收稿日期: 2022-01-24
- 修回日期: 2022-07-30
- 网络出版日期: 2024-03-07
- 刊出日期: 2022-12-20

Experimental Research on Vibration Characteristics of Viaduct Operation EMU Based on Unsteady Aerodynamic Characteristics

HUANG Zundi^{1, 2
,},
CHANG Ning^{1,*
, ,}

1.
School of Rail Transportation, Wuyi University, Jiangmen 529020
2.
School of Traffic & Transportation Engineering, Central South University, Changsha 410075

摘要

摘要: 定常横风引起的非定常气动特性影响高架运行列车的安全性和舒适性。开展定常横风下高架动车组的风洞试验，测试记录其车体表面压力时程曲线，进而分析其非定常气动特性及振动特性。试验结果表明，同一侧滑角同一风速下，车体中部同一侧测点的时程压力平均值差别不大，基本相等。当侧滑角保持90°不变时，测点气动压力的平均值、最大值和最小值与合成风速的二次方成正比；随着风速的增加，测点非定常压力波动加剧，波动幅度显著增大。当合成风风速保持60 m/s不变时，测点气动压力的平均值、最大值和最小值与侧滑角的1.27次方成正比；随着侧滑角的增大，测点的峰峰值呈现抛物线变化规律，非定常波动幅度先减小后增大。高架动车组车体的主振频率带随横风风速的增大基本保持不变，随侧滑角的增大基本保持不变；振动频率均在0~18 Hz范围内，并明显存在几个主要振动频率带，分别为8~10 Hz、0~2 Hz、14~16 Hz及16~18 Hz。

定常横风引起的非定常气动特性影响高架运行列车的安全性和舒适性。开展定常横风下高架动车组的风洞试验，测试记录其车体表面压力时程曲线，进而分析其非定常气动特性及振动特性。试验结果表明，同一侧滑角同一风速下，车体中部同一侧测点的时程压力平均值差别不大，基本相等。当侧滑角保持90°不变时，测点气动压力的平均值、最大值和最小值与合成风速的二次方成正比；随着风速的增加，测点非定常压力波动加剧，波动幅度显著增大。当合成风风速保持60 m/s不变时，测点气动压力的平均值、最大值和最小值与侧滑角的1.27次方成正比；随着侧滑角的增大，测点的峰峰值呈现抛物线变化规律，非定常波动幅度先减小后增大。高架动车组车体的主振频率带随横风风速的增大基本保持不变，随侧滑角的增大基本保持不变；振动频率均在0~18 Hz范围内，并明显存在几个主要振动频率带，分别为8~10 Hz、0~2 Hz、14~16 Hz及16~18 Hz。
- 非定常气动特性 /
- 高架 /
- 动车组 /
- 振动特性 /
- 试验研究
Abstract: An unsteady aerodynamic characteristics caused by steady crosswind affect the safety and comfort of viaduct operation train. The wind tunnel test of viaduct operation electric multiple units(EMU) under steady cross wind is carried out. The time-history curve of the surface pressure of the car body is tested and recorded to analyze its unsteady aerodynamic characteristics and vibration characteristics. The test results show that: under the same sideslip angle and the same wind speed, the average value of the time course pressure at the same side of car body is not much different, and is basically equal. When the sideslip angle remains unchanged at 90°, the average, maximum and minimum values of the aerodynamic pressure at the measuring point are proportional to the square of the synthetic wind speed; as the wind speed increases, the unsteady pressure fluctuations at the measuring point increase and the fluctuation amplitude is significant increase. When the synthetic wind speed is maintained at 60 m/s, the average, maximum and minimum values of the aerodynamic pressure at the measuring point are proportional to the 1.27 th power of the sideslip angle; as the sideslip angle increases, the peak-to-peak value at the measuring point appears parabolic change law, the amplitude of unsteady fluctuation first decreases and then increases. The main vibration frequency band of viaduct operation EMU coach remains unchanged with the increase of the crosswind wind speed and the same with the increase of the sideslip angle; the vibration frequency of two sides are both in the range of 0-18 Hz, and there are obviously several main vibrations frequency bands are 8-10 Hz, 0-2 Hz, 14-16 Hz and 16-18 Hz respectively.
- unsteady aerodynamic characteristics /
- viaduct /
- EMU /
- vibration characteristics /
- experimental research

HTML全文

图 1 风洞试验模型(m)

下载: 全尺寸图片幻灯片

图 2 风洞试验模型及测点布置

下载: 全尺寸图片幻灯片

图 3 静压测点及9-16测点

下载: 全尺寸图片幻灯片

图 4 侧滑角的定义

下载: 全尺寸图片幻灯片

图 5 不同测点时程压力平均值

下载: 全尺寸图片幻灯片

图 6 测点压力时程曲线

下载: 全尺寸图片幻灯片

图 7 非定常气动压力规律

下载: 全尺寸图片幻灯片

图 8 非定常气动压力规律

下载: 全尺寸图片幻灯片

图 9 不同测点振动特性

下载: 全尺寸图片幻灯片

图 10 不同风速振动特性

下载: 全尺寸图片幻灯片

图 11 不同侧滑角振动特性

下载: 全尺寸图片幻灯片

表 1 非定常气动压力数据

风速/(m/s)	平均值/Pa	最大值/Pa	最小值/Pa	幅值/Pa
10	48.28	54.22	42.56	11.66
15	112.72	119.52	103.58	15.94
20	199.73	207.76	191.87	15.89
25	312.38	323.59	295.98	27.61
30	444.58	461.89	430.02	31.87
35	604.67	621.24	583.11	38.13
40	791.11	811.17	762.67	48.50
45	998.60	1 027.04	957.31	69.73
50	1 223.41	1 253.95	1 178.96	74.99
55	1 471.04	1 516.08	1 410.12	105.96
60	1 794.96	1 856.74	1 719.91	136.83

下载: 导出CSV

表 2 非定常气动压力数据

侧滑角/(°)	平均值/Pa	最大值/Pa	最小值/Pa	幅值/Pa
15	211.63	280.62	132.69	147.93
30	451.11	508.25	398.43	109.82
45	944.66	991.05	892.85	98.20
60	1 355.32	1 401.43	1 309.66	91.78
75	1 674.38	1 723.99	1 616.42	107.57
90	1 794.96	1 856.74	1 719.91	136.83

下载: 导出CSV

参考文献(15)

[1]	马静, 张杰, 杨志刚. 横风下高速列车非定常空气动力特性研究[J]. 铁道学报, 2008, 30(6): 109-114. https://www.cnki.com.cn/Article/CJFDTOTAL-TDXB201002004.htm MA Jing, ZHANG Jie, YANG Zhigang. Study on the unsteady aerodynamic characteristics of a high-speed train under cross wind[J]. Journal of the China Railway Society, 2008, 30(6): 109-114. https://www.cnki.com.cn/Article/CJFDTOTAL-TDXB201002004.htm
[2]	杨志刚, 马静, 陈羽, 等. 横风下不同行驶工况下高速列车非定常空气动力特性[J]. 铁道学报, 2010, 32(2): 18-23. https://www.cnki.com.cn/Article/CJFDTOTAL-TDXB201002004.htm YANG Zhigang, MA Jing, CHEN Yu, et al. The unsteady aerodynamic characteristics of a high-speed train in different operating conditions under cross wind[J]. Journal of the China Railway Society, 2010, 32(2): 18-23. https://www.cnki.com.cn/Article/CJFDTOTAL-TDXB201002004.htm
[3]	刘加利, 于梦阁, 张继业, 等. 基于大涡模拟的高速列车横风运行安全性研究[J]. 铁道学报, 2011, 33(4): 13-21. https://www.cnki.com.cn/Article/CJFDTOTAL-TDXB201104005.htm LIU Jiali, YU Mengge, ZHANG Jiye, et al. Study on running safety of high-speed train under crosswind by large eddy simulation[J]. Journal of the China Railway Society, 2011, 33(4): 13-21. https://www.cnki.com.cn/Article/CJFDTOTAL-TDXB201104005.htm
[4]	刘加利, 张继业, 张卫华. 基于大涡模拟的横风下高速列车非定常气动载荷特性[J]. 铁道学报, 2013, 35(6): 13-21. https://www.cnki.com.cn/Article/CJFDTOTAL-TDXB201306004.htm LIU Jiali, ZHANG Jiye, ZHANG Weihua. Study on characteristics of unsteady aerodynamic loads of a sigh-speed train under crosswinds by large eddy simulation[J]. Journal of the China Railway Society, 2013, 35(6): 13-21. https://www.cnki.com.cn/Article/CJFDTOTAL-TDXB201306004.htm
[5]	郗艳红, 毛军, 高亮, 等. 横风作用下高速列车转向架非定常空气动力特性[J]. 中南大学学报, 2014, 45(5): 1705-1714. https://www.cnki.com.cn/Article/CJFDTOTAL-ZNGD201405045.htm XI Yanhong, MAO Jun, GAO Liang, et al. Aerodynamic force/moment for high-speed train bogie in crosswind field[J]. Journal of Central South University (Science and Technology), 2014, 45(5): 1705-1714. https://www.cnki.com.cn/Article/CJFDTOTAL-ZNGD201405045.htm
[6]	郗艳红, 毛军, 高亮, 等. 基于分离涡方法的高速列车横风非定常气动特性[J]. 中南大学学报, 2015, 46(3): 1129-1139. XI Yanhong, MAO Jun, GAO Liang, et al. Aerodynamic force/moment for high-speed train in crosswind field based on DES[J]. Journal of Central South University, 2015, 46(3): 1129-1139.
[7]	张亮, 张继业, 李田, 等. 横风下高速列车的非定常气动特性及安全性[J]. 机械工程学报, 2016, 52(6): 124-135. doi: 10.3901/JME.2016.06.124 ZHANG Liang, ZHANG Jiye, LI Tian, et al. Unsteady aerodynamic characteristics and safety of high-speed trains under crosswinds[J]. Journal of Mechanical Engineering, 2016, 52(6): 124-135. doi: 10.3901/JME.2016.06.124
[8]	常宁, 梁习锋, 黄尊地, 等. 基于橫风非定常的CRH₆横截面优化研究[J]. 铁道科学与工程学报, 2018, 15(11): 2730-2737. https://www.cnki.com.cn/Article/CJFDTOTAL-CSTD201811002.htm CHANG Ning, LIANG Xifeng, HUANG Zundi, et al. Optimization research on cross-section of CRH₆ by unsteady aerodynamic characteristics under crosswind[J]. Journal of Railway Science and Engineering, 2018, 15(11): 2730-2737. https://www.cnki.com.cn/Article/CJFDTOTAL-CSTD201811002.htm
[9]	李玉坤, 周丹. 强侧风下城际动车组非定常气动特性研究[J]. 铁道科学与工程学报, 2018, 15(11): 2721-2729. https://www.cnki.com.cn/Article/CJFDTOTAL-CSTD201811001.htm LI Yukun, ZHOU Dan. Study on the unsteady aerodynamic characteristics of a intercity emu under strong crosswind[J]. Journal of Railway Science and Engineering, 2018, 15(11): 2721-2729. https://www.cnki.com.cn/Article/CJFDTOTAL-CSTD201811001.htm
[10]	柳润东, 毛军, 郗艳红. 高速铁路风障在横风与列车风耦合作用下的气动特性研究[J]. 振动与冲击, 2018, 37(3): 153-159. https://www.cnki.com.cn/Article/CJFDTOTAL-ZDCJ201803026.htm LIU Rundong, MAO Jun, XI Yanhong. Aerodynamic load features of windbreaks of high speed railway under coupled action of cross wind and high speed train wind[J]. Journal of Vibration and Shock, 2018, 37(3): 153-159. https://www.cnki.com.cn/Article/CJFDTOTAL-ZDCJ201803026.htm
[11]	HASSAN H, CHRIS B. Large-eddy simulation of the flow around a freight wagon subjected to a crosswind[J]. Computers & Fluids, 2010, 39(10): 1944-1956.
[12]	TRISTAN F, GUNILLA E. An assessment of detached-eddy simulations of unsteady crosswind aerodynamics of road vehicles[J]. Flow, Turbulence and Combustion, 2011, 87(1): 133-163.
[13]	ASRESS M B, ALEKSANDAR S, JELENA S, et al. Aerodynamic characteristics of high speed train under turbulent cross winds: A numerical investigation using unsteady-RANS method[J]. Article in FME Transactions, 2014, 42(1): 10-18.
[14]	黄尊地, 池茂儒, 冯永华, 等. 横风作用下跨线运行动车组转向架气动力变化规律研究[J]. 机械工程学报, 2020, 56(22): 219-226. doi: 10.3901/JME.2020.22.219 HUANG Zundi, CHI Maoru, FENG Yonghua, et al. Study on the aerodynamic change law of EMU bogies of running-across-lines under cross-wind effect[J]. Journal of Mechanical Engineering, 2020, 56(22): 219-226. doi: 10.3901/JME.2020.22.219
[15]	公衍军, 黄尊地, 常宁. 横风环境高架运行的城际动车组车体气动载荷分析[J]. 铁道科学与工程学报, 2020, 17(11): 2748-2755. https://www.cnki.com.cn/Article/CJFDTOTAL-CSTD202011005.htm GONG Yanjun, HUANG Zundi, CHANG Ning. Aerodynamic load analysis of intercity EMU car bodies operating on the viaduct under cross-wind environment[J]. Journal of Railway Science and Engineering, 2020, 17(11): 2748-2755. https://www.cnki.com.cn/Article/CJFDTOTAL-CSTD202011005.htm